###
食品研究与开发:2024,45(23):77-86
本文二维码信息
码上扫一扫!
保水及杀菌方式对高水分即食虾仁品质的影响
(1.中国海洋大学三亚海洋研究院,海南 三亚 572000;2.中国海洋大学食品科学与工程学院,山东 青岛 266500)
Effects of Water Retention and Sterilization Methods on Quality of Ready-to-Eat Shrimp with High Moisture Content
(1.Sanya Oceanographic Institution,Ocean University of China,Sanya 572000,Hainan,China;2.College of Food Science and Engineering,Ocean University of China,Qingdao 266500,Shandong,China)
摘要
图/表
参考文献
相似文献
本文已被:浏览 43次   下载 13
投稿时间:2024-01-19    
中文摘要: 为探究复合保水剂和3 种不同杀菌方式处理对凡纳滨对虾高水分即食虾仁品质的影响,通过前保水和后保水的两步保水方法对虾仁进行保水处理,以蒸煮损失率和出品率为分析指标,制备一种低磷的保水剂。采用反压杀菌、巴氏杀菌和超高压杀菌处理高水分即食虾仁,以杀菌出品率、离心损失率、挥发性盐基氮(total volatile basic nitrogen,TVB-N)含量、全质构分析(texture profile analysis,TPA)、色差和感官评价等为指标,考察虾仁品质的变化。最终确定复合保水剂溶液浓度的最佳配比为前保水2.6%复合磷酸盐和2.0%海藻糖,后保水1.5%黄原胶、2.0%木薯磷酸酯淀粉和1.0%碳酸氢钠,此时虾仁的蒸煮损失率为20.99%,出品率为85.43%。与未杀菌组对比,超高压杀菌对蛋白质、肌肉和虾青素的破坏最小,保水性最好,TVB-N 含量最低,对虾仁品质的影响最小;而反压杀菌对虾仁品质的影响最大。
Abstract:In order to explore the effects of compound water retaining agents and three different sterilization methods on the quality of ready-to-eat shrimps of Litopenaeus vannamei with high moisture content,the shrimps were treated with two steps of water retaining method,namely front water retention and back water retention,and a low phosphorus water retaining agent was prepared according to the analysis indexes of cooking loss rate and production rate.The ready-to-eat shrimps with high moisture content were treated by reverse pressure sterilization,pasteurization,and ultra-high pressure sterilization(UHPS).The quality of the shrimps was observed with sterilization yield,centrifugal loss rate,total volatile basic nitrogen(TVB-N)content,texture profile analysis(TPA),color difference,and sensory evaluation as indexes.Finally,the optimal ratio of solution concentration of the compound water retaining agent was determined as 2.6% compound phosphate and 2.0% trehalose for front water retention,as well as 1.5% xanthan gum,2.0% cassava starch phosphate,and 1.0% sodium bicarbonate for back water retention. In this case,the cooking loss rate of the shrimps was 20.99%,and the yield was 85.43%.Compared with the unsterilized group,UHPS had the least damage to protein,muscle,and astaxanthin,the best water retention,the lowest TVB-N content,and the least effect on shrimp quality,while reverse pressure sterilization had the most effect on shrimp quality.
文章编号:202423011     中图分类号:    文献标志码:
基金项目:海南省重点研发计划项目(ZDYF2022XDNY191);海南省科技计划三亚崖州湾科技城科技创新联合项目(2021CXLH0006)
引用文本:


用微信扫一扫

用微信扫一扫